宋陵礦山設備專家認為，干法篩分時應先將標準試驗篩按順序套好，把試樣倒入最上層篩面上，蓋上頂蓋，放到振篩機上篩分15分鐘左右，然后將最下層篩子取下，用手持篩子在橡膠布火光面紙上進行檢查篩分。如果一分鐘內所得篩下物料量小于篩上物料量得0.1-0.5%，就可以認為篩析已達終點，否則還有放回振篩機上繼續篩分。篩分結束后，將各粒級產品倒出稱量。為清除篩孔中的難篩顆粒，可將篩子倒置，然后用手輕輕拍擊篩框，使嵌在孔中的顆粒振落，也可使用軟毛刷清掃，但對100微米以下的篩網，毛刷常使篩絲扭曲，篩孔變形。篩孔堵塞過多時，須置水中用超聲波清洗干凈，才能供下次使用。篩分損失量不應超過0.5-1%。

含泥多的粘結性物料，須采用干、濕聯合法篩析。此時可先將試樣用水浸濕泡散，或直接倒在細孔篩上，用手持篩子在水盆內進行篩分。為提高篩分效率，應將篩子不斷地搖動，但不要提出水面。盆中水過度渾濁時須另換一盆清水繼續篩分，直至盆中水不再變濁為止。然后將篩上物料烘干并稱重，再按干法進行篩析，底層篩篩下物料與濕篩時篩下的細泥合并，篩上各級分布收集。近年來已設計出可供濕法篩析用的套篩和振篩機，水流從頂蓋上的噴流水管給入，經各層篩網，由底盤側邊排水管流出。

篩析所需試樣的最小重量取決于最大粒的尺寸。每次給入成套試驗篩的試樣量以25-150克為宜。如果超過很多，就應分幾次篩分。直接用75微米篩濕篩時，每次篩分試樣量不宜超過50克。不適宜于濕篩的細物料，可使用氣流噴射篩篩析。

宋陵選礦咨詢電話：0371-64373366   技術熱線：18239939952   公司網站：//gzhqcs.com